[1]刘钰龙,刘小利,唐 凯.厄瓜多尔Parahuacu油田低压高渗小间隙尾管固井技术[J].复杂油气藏,2021,14(02):94-99.[doi:10.16181/j.cnki.fzyqc.2021.02.018]
 LIU Yulong,LIU Xiaoli,TANG Kai.Liner cementing technology with low pressure and high permeability,and small gaps in Parahuacu Oilfield,Ecuador[J].Complex Hydrocarbon Reservoirs,2021,14(02):94-99.[doi:10.16181/j.cnki.fzyqc.2021.02.018]
点击复制

厄瓜多尔Parahuacu油田低压高渗小间隙尾管固井技术
分享到:

《复杂油气藏》[ISSN:1674-4667/CN:31-2019/TQ]

卷:
14
期数:
2021年02期
页码:
94-99
栏目:
油气工程
出版日期:
2021-06-25

文章信息/Info

Title:
Liner cementing technology with low pressure and high permeability,and small gaps in Parahuacu Oilfield,Ecuador
作者:
刘钰龙12 刘小利12唐 凯 12
1.川庆钻探工程有限公司钻采工程技术研究院,陕西 西安 710021;2.低渗透油气田勘探开发国家工程实验室,陕西 西安 710021
Author(s):
LIU Yulong12LIU Xiaoli12TANG Kai12
1. Drilling and Production Research Institute,ChuanQing Drilling Engineering Limited,Xi'an 710021,China;2. National Engineering Laboratory for Exploration and Development of Low Permeability Oil & Gas Field,Xi’an 710021,China
关键词:
增产项目 尾管固井储层保护低压高渗油水活跃小间隙厄瓜多尔Parahuacu油田
Keywords:
production stimulation projectliner cementingreservoir protection low pressure and high permeabilityactive oil and waternarrow gapParahuacu OilfieldEcuador
分类号:
TE256
DOI:
10.16181/j.cnki.fzyqc.2021.02.018
文献标志码:
A
摘要:
Parahuacu油田位于厄瓜多尔56、57油区,该油田已进入开发的中后期,主力油藏为NAPO组U、T层砂岩,属于低压高渗储层,部分地层油水活跃。针对尾管固井对油层封固质量和油层孔隙低伤害的双重要求,通过研究固井对储层伤害、水泥浆防水窜及前置液界面增强机理等,优选了低密度减轻材料HGS6000、低密度悬浮稳定剂BCJ-310S、界面增强剂SS-5L,形成了低伤害防窜水泥浆体系、复合酸性界面增强前置液体系及配套工艺技术,解决了低密度水泥浆强度低稳定性差、水泥浆污染储层、水泥环界面胶结强度低等问题。前期施工的两口井油层优质率100%,尾管全井段优质率90%,投产后日均增产原油10 m3/d,原油含水率下降3%,显示了良好的应用效果,为后续尾管固井施工提供了技术支撑,为该油田持续增产稳产创造了良好条件。
Abstract:
The Parahuacu Oilfield is located in Block 56 and 57 of Ecuador,which has entered the middle and late stages of development. The main oil reservoirs are sandstones in the U and T layers of the NAPO Formation,which are low-pressure and high-permeability reservoirs with active oil and water in some formations.Aiming at the dual requirements of liner cementing for oil-layer sealing quality and low layer-pore damage,low-density mitigation material HGS6000,low-density suspension stabilizer BCJ-310S,and interface enhancement additive SS-5L were optimized by researching on damage mechanism of cementing to the oil reservoir,anti-water channeling mechanism of cement slurry,and interface enhancement mechanism of pad fluid,etc.It was formed the low damage and anti-channeling cement slurry,the composite acid interface enhancement pre-fluid system,and supplementary techniques,which solve the problems of low-density cement slurry with low strength and poor stability,cement slurry pollution to the reservoir,and low cement ring interface cement strength.The oil layer quality rate of the two wells constructed in the early stage was 100%,and the quality rate of the whole liner section was 90%.The average daily oil production was increased by 10 m3/d,and the water cut of crude oil was decreased by 3% after putting into production,showing a good application effect.The cementing operation provides technical support and creates good conditions for the oilfield to continuously increase and stabilize production.

参考文献/References:

[1]顾军.保护油气层水泥浆的研究与实践[J].石油钻采工艺,2000,22(6):7-10.
[2]顾军,张光华,王东国,等.非渗透性低失水水泥浆保护储层的机理研究[J].天然气工业,2006,26(10):77-79.
[3]王琼,胡晋军,耿志山,等.渤海湾埕海新区水平井固井配套油气层保护技术[J].钻井液与完井液,2019,36(4):491-494.
[4]冯文革,李应旭,王平,等.长庆油田侏罗系油藏固井技术研究与应用[J].石油钻采工艺,2012,34(3):44-47.
[5]姚晓.调整井固井水窜的根源及现行防水窜技术评析[J].钻井液与完井液,2001,18(5):13-16,20.
[6]刘钰龙.触变早凝膨胀水泥浆体系在厄瓜多尔TAMBOCOCHA区块尾管固井中的应用[J].钻井液与完井液,2019,36(6):754-758.
[7]罗长吉,刘爱玲,程艳.固井防水窜机理研究与应用[J].石油钻采工艺,1995,17(5):35-42+106.
[8]韦庭丛,郭小阳,程小伟,等.卡拉赞巴斯油田浅层调整井防窜固井技术[J].石油钻采工艺,2015,37(5):49-53.
[9]张宏军.中空玻璃微球超低密度水泥浆体系评价与应用[J].石油钻采工艺,2011,33(6):41-44.
[10]滕兆健,邢秀萍,常燕.空心玻璃微珠低密度水泥浆的初步研究[J].钻井液与完井液,2011,28(z1):23-25.
[11]卢海川,邢秀萍,谢承斌,等.新型固井悬浮剂的开发[J].钻井液与完井液,2014,31(1):60-63.
[12]焦利宾,姚坤全,李成全,等.固井用隔离液材料对界面胶结质量的影响[J].钻采工艺,2019,42(3):104-107.
[13]陈大钧,雷鑫宇,李芹,等.双重强化界面胶结强度技术[J].钻井液与完井液,2014,31(1):57-59.
[14]刘振通,宋志强,王军,等.硅酸钠前置液在委内瑞拉重油带固井中的应用[J].钻井液与完井液,2015,32(6):96-99.
[15]杨宝林,顾军,郑涛,等.泥饼厚度对固井二界面胶结强度的影响[J].钻井液与完井液,2009,26(1):42-43,46.
[16]郭小阳,张凯,李早元,等.超深井小间隙安全注水泥技术研究与应用[J].石油钻采工艺,2015,37(2):39-43.

备注/Memo

备注/Memo:
收稿日期:2020-07-17;改回日期:2020-09-09。
第一作者简介:刘钰龙(1988—),工程师,主要从事水泥浆现场技术服务工作。E-mail:605347994@qq.com。
更新日期/Last Update: 2021-06-30